Navistar Recalls
33 recalls on record · June 5, 1991 to August 26, 2014 · Vehicle Equipment, Vehicles
Recalls by year
91
92
97
98
99
00
14
Count of recall notices naming this brand, by the year the recall was announced. A quiet year is not proof of a safe year.
August 26, 2014Vehicle EquipmentNHTSA
Navistar Equipment recall
Hazard: Warning triangles that do not properly reflect light may fail to warn others that a vehicle is parked, increasing the risk of a crash.
January 24, 2000VehiclesNHTSA
Navistar 1999 Service Brakes, Hydraulic recall
Hazard: THE REAR BRAKES CAN BE APPLIED AUTOMATICALLY DURING A TRACTION EVENT AND NOT RELEASE UNTIL THE AIR SYSTEM PRESSURE IS DEPLETED.
December 14, 1999VehiclesNHTSA
Navistar 1994–1999 Service Brakes, Air recall
Hazard: THIS COULD RESULT IN A LONGER STOPPING DISTANCE OR A DRAGGING BRAKE CONDITION.
December 14, 1999VehiclesNHTSA
Navistar 1999 Service Brakes, Air recall
Hazard: INCREASED BRAKING EFFORT MAY BE REQUIRED.
September 21, 1999VehiclesNHTSA
Navistar 1998–1999 Fuel System, Gasoline recall
Hazard: IF THE CROSS MEMBER IS EITHER MISSING OR RELOCATED THE VEHICLE MAY NOT HAVE ADEQUATE FUEL TANK PROTECTION. IN THE EVENT OF A CRASH, THE BUS MAY NOT HAVE ADEQUATE FUEL TANK PROTECTION IF THE VEHICLE HAS A MISSING OR IMPROPERLY INSTALLED CROSSMEMBER.
September 21, 1999VehiclesNHTSA
Navistar 1999 Service Brakes, Hydraulic recall
Hazard: IF A HOSE RUPTURES, THE REAR BRAKES WILL FAIL INCREASING THE RISK OF A VEHICLE CRASH.
September 21, 1999VehiclesNHTSA
Navistar 1997–1999 Parking Brake recall
Hazard: THE PARKING BRAKE WILL AUTOMATICALLY APPLY IF PRESSURE IS LOST DUE TO A RUPTURED PARK BRAKE HOSE INCREASING THE RISK OF A VEHICLE CRASH.
September 20, 1999VehiclesNHTSA
Navistar 1999 Visibility recall
Hazard: IF THE WIRE INSULATION IS MELTED ENOUGH TO CREATE A SHORT, THE POTENTIAL FOR A FIRE EXISTS. THIS SHORT CAN ALSO OPEN THE CIRCUIT THAT CONTROLS ALL THE MARKER AND TAIL LIGHTS. IF THE TAIL AND MARKER LIGHTS GO OUT, THE VEHICLE COULD CAUSE A CRASH.
August 3, 1999VehiclesNHTSA
Navistar 1999 Steering recall
Hazard: IF THE STEERING COLUMN BROKE, A COMPLETE LOSS OF STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
July 15, 1999VehiclesNHTSA
Navistar 1996–1998 Suspension recall
Hazard: THIS FATIGUE CRACKING CAN RESULT IN WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
May 4, 1999VehiclesNHTSA
Navistar 1999 Visibility recall
Hazard: SHOULD A FAILURE OCCUR DURING INCLEMENT WEATHER ON THE DRIVER'S SIDE WHILE THE VEHICLE IS IN MOTION, THE OPERATOR'S VISION WOULD BE PARTIALLY OBSCURED.
March 16, 1999VehiclesNHTSA
Navistar 1999 Service Brakes, Air recall
Hazard: WITHOUT SUFFICIENT TORQUE ON THE GUIDE PAWL CAP SCREW, THE BRAKES COULD GRADUALLY LOSE ADJUSTMENT, INCREASING THE VEHICLE STOPPING DISTANCE.
March 15, 1999VehiclesNHTSA
Navistar 1998–1999 Suspension recall
Hazard: IF THE SPINDLE FAILS, A LOSS OF DRIVER CONTROL COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
February 16, 1999VehiclesNHTSA
Navistar 1996–1998 Steering recall
Hazard: SEPARATION OF THE TIE ROD END COULD RESULT IN LOSS OF STEERING CONTROL, INCREASING THE RISK OF A VEHICLE CRASH.
November 9, 1998VehiclesNHTSA
Navistar 1997–1998 Engine And Engine Cooling recall
Hazard: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A FIRE.
November 9, 1998VehiclesNHTSA
Navistar 1997–1999 Power Train recall
Hazard: IF THIS CONDITION OCCURS, THE DRIVE LINE CAN VIBRATE AND SEPARATE FROM THE VEHICLE, CAUSING VEHICULAR DAMAGE, OR PERSONAL INJURY, OR BOTH.
November 9, 1998VehiclesNHTSA
Navistar 1998–1999 Fuel System, Gasoline recall
Hazard: IF THIS CONDITION OCCURS, THE HOSE WILL FAIL, RESULTING IN A SUDDEN LOSS OF OIL, CAUSING THE ENGINE TO HAVE A SUDDEN LOSS OF POWER.
September 17, 1998VehiclesNHTSA
Navistar 1998–1999 Service Brakes, Hydraulic recall
Hazard: BOLTS WILL EVENTUALLY WORK OUT OR SHEAR RESULTING IN DRUM AND DRIVE SHAFT SEPARATION.
July 28, 1998VehiclesNHTSA
Navistar 1992–1995 Steering recall
Hazard: IF THIS OCCURS, A FAILURE OF THE TIE ROD ARM COULD RESULT IN A LOSS OF STEERING CONTROL TO THE RIGHT WHEEL.
June 16, 1998VehiclesNHTSA
Navistar 1997 Wheels recall
Hazard: THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.
May 27, 1998VehiclesNHTSA
Navistar 1994–1997 Power Train recall
Hazard: THE VEHICLE CAN MOVE AFTER BEING PLACED IN PARK INCREASING THE RISK OF A CRASH.
May 27, 1998VehiclesNHTSA
Navistar 1997–1998 Electrical System recall
Hazard: THIS CONDITION CAN RESULT IN A SHORT CIRCUIT BETWEEN CONTACTS ON THE RELAY INCREASING THE RISK OF A VEHICLE FIRE.
March 25, 1998VehiclesNHTSA
Navistar 1997–1998 Engine And Engine Cooling recall
Hazard: IF THE COMPRESSOR DISCHARGE LINE FAILS, THE AIR SYSTEM COULD BE DEPLETED AND CAUSE THE PARKING BRAKES TO APPLY. THIS CONDITION CAN CAUSE THE VEHICLE TO SLOW DOWN OR STOP UNEXPECTEDLY, CAUSING A VEHICLE CRASH WHICH COULD RESULT IN PROPERTY DAMAGE AND/OR PERSONAL INJURY.
November 24, 1997VehiclesNHTSA
Navistar 1997 Suspension recall
Hazard: CRACKS IN A HUB FLANGE CAN RESULT IN A WHEEL SEPARATION.
September 8, 1997VehiclesNHTSA
Navistar 1997 Vehicle Speed Control recall
Hazard: THE UNEXPECTED BREAKAGE CAN RESULT IN THE INABILITY TO ACCELERATE THE VEHICLE PROPERLY INCREASING THE RISK OF A VEHICLE CRASH.
September 8, 1997VehiclesNHTSA
Navistar 1997 Vehicle Speed Control recall
Hazard: THE UNEXPECTED BREAKAGE CAN RESULT IN THE INABILITY TO ACCELERATE THE VEHICLE PROPERLY INCREASING THE RISK OF A VEHICLE CRASH.
September 2, 1997VehiclesNHTSA
Navistar 1991–1994 Exterior Lighting recall
Hazard: IF THE TURN SIGNAL FUNCTION IS LOST, FOLLOWING MOTORISTS WOULD NOT BE AWARE OF THE TURNING VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.
July 29, 1997VehiclesNHTSA
Navistar 1997 Service Brakes, Hydraulic recall
Hazard: SHOULD THE ABS WIRING BE CROSSED, IT WOULD RESULT IN A SIGNIFICANT DEGRADATION IN BRAKING STABILITY. A SIGNAL WOULD BE SENT TO THE WRONG BRAKE CHAMBER WHEN A BRAKE IMBALANCE IS DETECTED INCREASING THE RISK OF A VEHICLE CRASH.
July 28, 1997VehiclesNHTSA
Navistar 1996–1997 Wheels recall
Hazard: STUD FAILURES CAN OCCUR RESULTING IN A WHEEL SEPARATION INCREASING THE RISK OF A VEHICLE CRASH.
May 28, 1997VehiclesNHTSA
Navistar 1991–1996 Power Train recall
Hazard: THIS CAN ALLOW THE CAM LEVER TO BECOME DISENGAGED FROM THE PARKING BRAKE SHOES. THE OPERATOR WOULD HAVE NO WARNING THAT THE PARKING BRAKE WAS NOT APPLIED ALLOWING THE VEHICLE TO MOVE UNEXPECTEDLY.