Thor Motor Coach Recalls

Hazard: An operator that smokes near the fuel fill station with flammable vapors present can increase the risk of a fire.

Hazard: A sudden loss of an engine brake without warning on a motorhome may lead to a reduced brake capacity, potentially increasing the risk of a crash.

Hazard: If the sway bar bolts loosen, the sway bar may detach from the axle, affecting the handling and increasing the risk of a crash.

Hazard: If the brake activation signal to a towed device remains active when the motorhome chassis service brakes are released, the brakes on a towed device may remain engaged depending on brake configuration of the trailer. As a result, the brakes would drag and possibly overheat potentially resulting in a fire. Additionally, following drivers may be confused by the motorhome's actions, increasing the risk of a crash.

Hazard: The steering wheel's connection to the front axle could fail resulting in a sudden loss of steering ability, increasing the risk of a crash.

Hazard: If the motorhome experiences an unexpected loss of power, it can increase the risk of a crash.

Hazard: If the seat belt anchorages pull loose in a crash, they will not properly restrain the occupant, increasing the risk of injury.

Hazard: Heat build-up in the vehicle storage compartment increases the risk of fire.

Hazard: Unstable entry and exit steps increase the risk of injury.

Hazard: If the parking brake does not fully engage, the vehicle may unexpectedly roll, increasing the risk of personal injury or a crash. A parking brake that drags may result in a wheel end fire.

Hazard: If the insert flips up when sat on, the occupant may fall, increasing the risk of injury.

Hazard: If the windshield cannot be defrosted, the driver's visibility may be affected, increasing the risk of a crash.

Hazard: If the vehicle is loaded to its weight capacity without including the weight of the water carried onboard, the motorhome may be overloaded. This can cause a loss of vehicle control, increasing the risk of a crash.

Hazard: If a vehicle that has an incorrectly installed abutting wedge is involved in a severe frontal crash, a greater force may be necessary to open the doors, increasing the risk of injury.

Hazard: The screws could fail, causing the supporting bracket to fail, and the awning to fall and potentially strike and injure a person beneath it.

Hazard: If an awning falls, there is an increased risk of injury to anyone under the awning.

Hazard: Loose stair treads can result in a person slipping and falling, increasing the risk of injury.

Hazard: Due to the exhaust's proximity and the lack of heat shielding, the hot exhaust piping could heat the propane tank and cause it to expand and vent off any build up of pressure, increasing the risk of a fire. The exhaust exiting below a slide out room may cause carbon monoxide to enter the vehicle, increasing the risk of asphyxiation.

Hazard: If the microwave starts on its own and there are contents inside, a fire could result.

Hazard: If the BCC fails, all power may be lost to the motorhome chassis, including all lighting, making the vehicle very difficult to operate, increasing the risk of a crash.

Hazard: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Hazard: Failure of the cruise control to disengage when the brakes are applied may increase the risk of a vehicle crash. Without the brake lights illuminating when the brakes are applied, the driver's intent is not communicated, increasing the risk of a crash.

Hazard: REDUCED BRAKE PERFORMANCE INCREASES THE RISK OF A CRASH.

Hazard: HEAT BUILD UP COULD RESULT IN A FIRE, PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Hazard: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Hazard: HEAT BUILD UP COULD RESULT IN A FIRE, PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Hazard: THE TANK CAN LOOSEN AND POTENTIALLY FALL OFF OF THE VEHICLE CREATING A ROAD HAZARD INCREASING THE RISK OF PERSONAL INJURY OR PROPERTY DAMAGE.

Hazard: AN ENGINE SHUT DOWN WHILE DRIVING INCREASES THE RISK OF A CRASH.