GEM 1999–2004 Electrical System recall
Recalled June 21, 2006 · NHTSA recall 06V222000 · GEM
Hazard
A LOSS OF HEADLAMPS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH. IF THERE IS A LOSS OF TAIL LAMP OR TURN SIGNAL LAMP FUNCTION, A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED OR THAT THE VEHICLE IN FRONT IS TURNING, A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
Units
27,350 units
Description
ON CERTAIN 2 AND 4 PASSENGER, SHORT AND LONG BED LOW SPEED VEHICLES, THE 12 VOLT OUTPUT FROM THE AUXILIARY CARD CIRCUIT BOARD (A DC VOLTAGE TO DC VOLTAGE CONVERTER) MAY BECOME INOPERATIVE AND RESULT IN LOSS OF HEADLAMP, TAIL LAMP AND TURN SIGNAL LAMP FUNCTIONS.
What to do
DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
Product
GEM NEV
Manufacturer(s)
GEM WAEV LLC
Source: U.S. National Highway Traffic Safety Administration. Official recall notice on nhtsa.gov →